Home > 7.62 x 51 mm NATO

The development work that would eventually develop into the 7.62x51 started just after World War I, when it became clear that the long cartridge of the US standard .30-06 round made it difficult to use in semi- and fully-automatic weapons. A "shorter" round would allow the firing mechanism to be made much smaller, and improve the feeding, both of which would allow for higher rates of fire. At the time one of the most promising designs was the .276 Pederson , but in 1932 it was rejected with an Army recommendation that only rounds of .30" would meet requirements.

Thus when the war appeared to be looming again only a few years later, the .30-06 was the only round available. Nevertheless the US Army did use it to great effect in the excellent M1 Garand, which gave US troops with considerably higher firepower than most of their bolt action armed opponents. The Garand was so good that the US saw little need to replace it until almost a decade later, and the .30-06 remained in service until well after the Korean War.

During the 1940's and early 1950s several experiments were carried out in order to improve upon the Garand. One of the most common complaints was the difficulty in reloading the weapon using its "stripper clips", and many experimental designs modified the weapon with a detachable box magazine. One of these, Springfield Armory's T22, was a fully-automatic version. The US Army finally found this design to be worthy enough to consider replacing the Garand, and decided it was also time to look at improved ammunition once again.

The test program continued for several years, including not only the original .30-06, but a modified .300 Savage and a new .308 Winchester design (then known as the T65) as well. In the end the Winchester Arms design demonstrated power roughly equal to the original .30-06, while being somewhat shorter and much more reliable in feeding. The T44, an adaptation of the T22 to fire the new round, was the almost-uncontested winner of the competion.

When the US announced its intentions to introduce the .308, the British were incensed. They had considerable evidence to demonstrate that their own .303 British could not be fired automatic, let alone the somewhat more powerful .308. They had spend considerable time and effort developing an intermediate-power round, the .280, to solve these problems.The US countered with their pre-WWII requirements that stated that only a .30 caliber design would do. After considerable fighting between the two armed forces, the argument was settled in unlikely fashion when the Canadian Army announced they would be happy to use the .280, but only if the US did as well -- a tacit agreement to use the .308, as it was clear the US would not use the .280. The T65 was chosen as the NATO standard in 1954.

Production of the T44 as the M14 started, with the first service rifles ariving in 1957. FN FAL's started delivery in England and Canada around the same time, with the West German army chosing their own design, the G3The G3 (G3A3) series battle rifle is manufactured by Heckler und Koch. The G3 is typical of its day, a battle rifle chambered in 7. 62 x 51 mm NATO, capable of semi-automatic or fully automatic fire and using a detachable magazine, like the FN FAL or the. However it was not long before those involved realized the British had been right all along, the .308 could not reliably be fired in full-auto due to recoil. M14's were later delivered with the full-auto selection locked out, and adaptations to the FAL to allow it included the addition of a bipod and heavier barrel.

While all of this was going on, the US's Project SALVO had concluded that a burst of four rounds into a 20" circle would cause twice the number of casualties as a full-auto burst by one of these "battle rifles" -- regardless of the size of the round. They suggested using a much smaller .22 caliber cartridge with two bullets per round (a "duplex load"), while other researchers investigated the promising flechetteThe word flechette is French and means "dart" (literally, "little arrow"). It is a projectile having the form of a small metal dart, usually steel, with a sharp-pointed tip and a tail with several vanes to stabilize it during flight. Flechettes were used rounds which were even lighter but offered better penetration than even the .30-06. These studies were kept secret in case the British found out about them and used that as evidence in favour of their smaller rounds.

When the M14 arrived in VietnamThe Socialist Republic of Vietnam is a country in Southeast Asia. It borders China, Laos, Cambodia, and the Gulf of Tonkin. Cng Hoa Xa Hi Ch Nghia Vit Nam ( In Detail) (Full size) National motto: Dc lp, t do, hnh phuc (Independence, Liberty, Happiness Off with US troops, it was quickly found to be no better than the Garand in combat. The long length meant that it was difficult to carry in the bush, and the heavy weight made it difficult to quickly swing into action in meeting engagements. The heavy ammunition also meant that the troops could carry only small amounts on patrols, and often found themselves being outgunned by the ever-increasing number of AK47's being used against them.

Fighting between the big-round and small-round groups reached a peak in the early 1960s, when test after test showed the "puny" .223 Remington round fired from the AR-15Colt AR-15 SP1 The AR-15 is a self-loading centerfire rifle designed by Eugene Stoner of the Armalite corporation who developed it as a smaller version of the AR-10. Armalite sold its rights to the AR-10 and AR-15 to Colt in 1959 after which the AR-15 was allowed an 8-man unit to vastly outgun an 11-man unit armed with M14's, and beat the typical NVA unit armed with AK47's. Perhaps more surprisingly, the M16 was considerably more reliable. In 1967 the US Army started replacing their M14's with the M16, setting off another firestorm of complaints from the British.

The 7.62 nevertheless proved itself an excellent mid-sized round, accomplishing everything the designers had hoped in terms of full-auto reliability. It remained the main squad machine gunA machine gun is a fully-automatic firearm that is capable of firing bullets in rapid succession. Overview M2 machine gun surrounded by spent shell casings Unlike semi-automatic firearms, which require one trigger pull per bullet fired, a machine gun will round for almost all NATO forces well into the 1990s, even being used in adapted versions of older .30-06 machine guns from the WWII era. These too have been replaced to some extent by .223 weapons, notably the widespread MINIMI , but they remain the primary armament on most flexible mountings such as helicopters, jeeps, and tanks.

Winchester saw the market for a civilian model of the round, and the .308 remains a popular game round to this day as the .308 Winchester. The cartridge is very popular with American sportsmen both for long-range target shooting and hunting big game up to the size of elk or moose.